Contents: Battery ⇓ Starter ⇓ Generator ⇓ Control and warning lights ⇓ Temperature indicator ⇓ Lighting system lamps ⇓ Speedometer ⇓ Tachometer ⇓ Fuel level indicator ⇓ Windshield wiper and washer ⇓ Tightening torques, Nm ⇓ General information ⇓ Precautionary measures ⇓
Battery
Type | MF 45 Ah | MF 60 Ah | MF 68 Ah |
| Amp hours (5HR) | More than 36 Ah | More than 48 Ah | More than 54 Ah |
| Current strength when turning the crankshaft of a cold engine | 380 A | 550 A | 600 A |
| Reserve capacity | 80 min | 92 min | 110 min |
| Electrolyte density at 25°C, g/cm³ | 1,280±0,01 | 1,280±0,01 | 1,280±0,01 |
Attention! The cranking current of a cold engine is the current that the battery can deliver for 30 seconds while maintaining a voltage of at least 7.2 V.
Attention! Reserve capacity is the time during which the battery can deliver a current of 25 A at a temperature of 26.7°C, while maintaining a voltage of at least 10.5 V.
Starter
Name | Petrol engines | Diesel engine |
| Type | With planetary gear | With planetary gear |
| Voltage | 12 V | 12 V |
| Nominal power | 1.2 kW | 2.0 kW |
| Idle characteristics | ||
| Ultimate stress | 11 B | 11.5 V |
| Current consumption | Not more than 90 A | Not more than 100 A |
| Rotation frequency | 2800 min⁻¹ | 4000 min⁻¹ |
| Number of gear teeth | 8 | 9 |
| Gear clearance | 0.5–2 mm | 0.5–2 mm |
Generator
Name | Petrol engines | Diesel engine |
| Nominal power | 13.5V/90A | 12V/120A |
| Voltage regulator type | Electronic built-in | Electronic built-in |
| Voltage regulator | 14.4±0.3 V | 14.7±0.3 V |
| Temperature compensation | –10±3 mV/°C | –10±3 mV/°C |
Control and warning lights
Lamps | Power, W | Color |
| Backlight lamps | 3,4/ LED | yellow green/ blue |
| High beam | 3,4/ LED | blue |
| Low fuel level | 3,0/ LED | amber |
| Turn signal | 1,4/ LED | green |
| Charging the battery | 1,4/ LED | red |
| Oil pressure | 1,4/ LED | red |
| Airbag | 1,4/ LED | red |
| Parking brake | 1,4/ LED | red |
| Seat belt | 1,4/ LED | red |
| Monitoring the operation of engine systems | 1,4/ LED | amber |
| ABS | 1,4/ LED | amber |
| Unclosed door | 1,4/ LED | red |
| The trunk lid is open | 1,4/ LED | red |
| Cruise control | 1,4/ LED | green |
| Fog lights | 1,4/ LED | green |
| Immobilizer | 1,4/ LED | amber |
| TCS | 1,4/ LED | amber |
| O/D switch – automatic transmission mode | 1,4/ LED | amber |
| Glow Plugs (Diesel) | 1,4/ LED | amber |
| Water Separator (Diesel) | 1,4/ LED | amber |
| Vacuum brake booster (Diesel) | 1,4/ LED | red |
| Automatic transmission | ||
R | 1,4/ LED | green |
N | 1,4/ LED | amber |
D | 1,4/ LED | green |
2 | 1,4/ LED | green |
3 | 1,4/ LED | green |
L | 1,4/ LED | green |
Temperature indicator
Temperature | Angle,° |
60°C | 0 |
85–110 | 38 |
Red sector (more than 125°C) | 87±5 |
Lighting system lamps
Lamps | Power, W |
| Headlight | 55/ 55 |
| Front turn signal | 21 |
| Front side marker light | 5 |
| Front fog lights | 55 |
| Rear lights: | |
| 5/21 |
| 21 |
| 21 |
| Rear fog lights | 21 |
| Side turn signal repeater | 5 |
| Interior lighting | 10 |
| High-mounted brake light | 21 |
| Interior lighting that turns on when the door is opened | 5 |
| License plate lighting | 5 |
Speedometer
Data | Meaning | ||||
| Speed, km/h | 20 | 40 | 60 | 80 | 100 |
| Tolerance, km/h | 20–24,4 | 40–43 | 60–64,4 | 80–85,5 | 100–105,2 |
| Speed, km/h | 120 | 140 | 160 | 180 | 200 |
| Tolerance, km/h | 120,5 –126 | 140,5–146 | 160,5–166 | 181–186,5 | 201–206,5 |
Tachometer
Data | Meaning | |||||
| Frequency, min⁻¹ | 1000 | 2000 | 3000 | 4000 | 5000 | 6000 |
| Tolerance, min⁻¹ | ±100 | ±125 | ±150 | ±170 | ±200 | ±240 |
Fuel level indicator
Level | Pointer | Admission with fuel level sensor |
Resistance, Ohm | ||
E (Empty) | 97 | 0±2,5 |
1/2 | 32,5 | 4 ±5,0 |
F (Full) | 6 | 90±2,5 |
Windshield wiper and washer
Name | Technical requirements | |
| Windshield wiper motor | Speed/current, 1.0 Nm | Slow: 44–52 min⁻¹/ no more than 3.5 A |
Fast: 66–80 min⁻¹/ max 4.5 A | ||
Speed/current, 3.9 Nm | Slow: 39–47 min⁻¹/ no more than 7 A | |
Fast: 57–69 min⁻¹/ max 9 A | ||
Current when blocking | Slow: no more than 24 A | |
Fast: no more than 28 A | ||
| Rear window wiper motor | Speed/current, no load | 48 min⁻¹/ no more than 2.0 A |
Speed/current, 1.0 Nm | 34–46 min⁻¹/ no more than 3.5 A | |
Current when blocking | no more than 9 A | |
Steering angle without load | 90° ±3° | |
| Washer pump capacity, cm³/min | 1500 | |
| Pressure generated by the pump, kg/cm² | 1,6 | |
| Uninterrupted operation | With water | 60 |
Without water | 20 | |
[The text is taken from an online source: HyundaiBook]
Tightening torques, Nm
Data | Meaning |
| Generator terminal (B+) | 5–7 |
| Starter terminal (B+) | 10–12 |
| Battery terminals | 4–6 |
| Spark plug | 20–30 |
| Glow plug | 15–20 |
| Glow plug busbar mounting nut | 1–1,5 |
General information
The negative ground electrical system has an operating voltage of 12 volts. Power for the electrical system comes from a lead-acid battery, which is recharged by the generator.
It should be noted that when working with any element of the vehicle's electrical equipment, the negative battery terminal wire must be disconnected to prevent short circuits and/or fire.
Check the location and fastening of the wires at regular intervals, and ensure that the wires do not rub against other elements. If you find that any wires are rubbing against other components, move the wires to the side and secure them so that this does not happen again.
Precautionary measures
It is prohibited to change the polarity of the power supply of various devices and electrical equipment in order to avoid failure of semiconductor devices.
Do not disconnect or connect the battery, measuring instruments or any wires while the engine is running.
It is prohibited to check the generator's serviceability by short-circuiting the power terminal to ground.