Steering Specifications Steering gear with hydraulic booster: 1 - tie rod end; 2 - right steering rod; 3 - a protective cover of steering draft; 4 - bracket and cushion for mounting the...
Steering malfunctions Feature Probable Cause Elimination method Increased steering wheel play Loose joint in universal joint Tighten Steering gear bolts not securely tightened Tighten the...
Steering check At each maintenance of the car, check the condition of the protective cover of the steering mechanism, the caps of the hinges of the rods and the tightness of their fit....
Steering wheel free play check 1. Start the engine with the steering wheel in the straight ahead position. 2. Measure the free play around the circumference of the steering wheel. Steering wheel free...
Checking the angle of rotation of the front wheels 1. Mount the front wheels on the turntable. Rotate the front wheels to the maximum angle and measure the steering angle of each wheel. Steering angle: Inner wheel:...
Checking the effort of turning the steering wheel 1. With the vehicle on a firm, level surface, set the front wheels to straight ahead. 2. Increase the engine speed to 1000±100 min -1 . 4. Check up that at turn of a...
Checking the power steering fluid level 1. Place Getz on a flat, level surface. 2. Start the engine and warm up the power steering fluid to a temperature of 50~60°C by turning the steering wheel from lock to...
Bleeding the hydraulic system of the power steering 1. Disconnect the high voltage wire from the ignition coil. Periodically turn on the starter for 15-20 seconds and at the same time turn the steering wheel from lock to...
Checking fluid pressure in the hydraulic system 1. Disconnect the pressure hose from the power steering pump. Connect a special measuring tool between the disconnected pressure hose and the pump, as shown in the...
Steering gear — removal and installation Vehicles without power steering Steering gear for vehicles without power steering: 1 – steering draft; 2 - anther; 3 - dust cap; 4 – a tip of steering draft; 5 – a...
Steering gear without power steering Withdrawal 1. Place the car on a lift and raise it. 10. Move the steering gear and get it on the right side of the car. Warning! Measure the preload at the full travel...
Steering gear of a car with power steering Withdrawal 1. Place the car on a lift and raise it. 6. Raise the vehicle. 7. Turn out a bolt of fastening of a clip of pressure head and returnable tubes of the...
Steering shaft — removal and installation Vehicles without electric power steering Steering column and steering shaft without steering wheel adjustment mechanism: 1 - lower shaft; 2 - dashboard beam; 3 – bolts...
Amplifier hoses — removal and installation Withdrawal 1. Place the car on a lift and raise it. 2. Drain the fluid from the power steering hydraulic drive. 3. Remove the front wheels. 4. Remove the cotter pins and...
Filling the Power Steering Mechanism with Fluid 1. Fill the power steering fluid reservoir up to the mark «MAX». 2. Raise the front wheels. Periodically turn on the starter for 15–20 s and at the same time turn the...
Power steering pump Withdrawal 1. Disconnect the pressure hose from the pump. Disconnect the suction filter from the suction pipe and drain the liquid into a container. 9. Using a 24 mm...
EPS electronic steering system The EPS steering column uses an electric motor to help turn the steering wheel. It is an independent control system. The EPS drives an electric motor to provide varying...